2012 ford focus transmission problems

Vehicles impacted are the Ford Fiesta (model years 2011-2016) and the Ford Focus (model years 2012-2016) equipped with a PowerShift transmission. Required an update and reflash of the tranny module. DCT transmission failure. They were ground up inside clutch and affected shifting of the car. The problems specifically occurred in the Powershift transmission of Ford Fiesta (from 2011-2016) and Ford Focus (from 2012- 2016). Customer satisfaction letter dated May 2012 offered reflashing of body control module, transmission module and ABS module to correct driveability concerns. Car stuttering from stop; software re flashed for DCT. Sometimes it hesitates when cresting a peak, mini-lurches when starting, or mini-surges at parking lot speeds. Nearly two â¦ The clutch was replaced along with a newer updated seal. Horrible shifting experiences. Clutch was completely replaced as per technical service bulletin. I realized that there was a recall on the transmission and the TCM. I had to have it towed. Worried about potential repair costs? Also reprogrammed the PCM/TCM, Grinding noise from 1st to 2nd. Transmission shudders while accelerating. Learned from online forums that problem plagues clutches on many new Focus and Fiesta. It's one week now at the dealer and no action. Start issue came back. 2012 Ford Focus transmission problems with 281 complaints from Focus owners. Re-programmed TCM and then car failed to shift out of 2nd gear. Part of a TSB and covered under the original factory warranty. First stage clutch replaced again (see repairs when car was new) for delay and shuddering. Control update for this problem released in April 13 For more information on how we collect and use this information, please review our Privacy Policy. Typical problem with the new automated manual transmission: lurching, poor idle. Wheel disconnected from car @ CV Joint and axel rod. they re programmed the computer in car. The most recently reported issues are listed below. It did learn me perfectly in 6 weeks. © 2004 - 2021 TrueDelta. Clutch and seals replaced under warranty. As of 8/16- still at dealer. Their services are at no cost to the consumer. Car would not start first time you turn the key. ps: car is delivering an honest 38+ MPG on the road, drops to about 34 in town. I've had ongoing issues with the transmission and clutch since purchasing new. Removed transmission, replaced clutch assy. Ford has proposed an updated settlement of a minimum of $30 million in cash reimbursement in a class-action lawsuit over problems with dual-clutch automatic transmissions in Focus â¦ Check engine light came on and car lost power to the wheels while on the highway. Ford F-150 Oil Consumption Issues Cause Lawsuit, read stories from drivers who praise our work. Dealership stated: Caused by-NORMAL, No problem Found. See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. The affected vehicles are 2011 to 2016 Fiestas and 2012 to 2016 Focus models. "Learned" again, but not good. Privacy Policy | Terms and Conditions | Copyright Policy | Michael at Google+. vehicle shuddered when shifting between 2nd and 3rdÂ¦ hunted for the right gear, revved excessively before shifting. Chart based on 95 repair trips. Along with an update on the transmission software. Now much better but still.. Covered under extended warranty with $100 deductible. Factory recall on transmission/shifting performed because car showed some sluggishness when shifting. Won case in arbitration in June. A week later, my service charge was refunded when I ran the issue up the flagpole. Performed diagnostic that showed issue. New TCM installed under warranty. Car bought back. I had a small shudder and slipping from the clutches. This is third trip in 3 months for same problem. Worse when driving on incline, shudder when shifting. Opened a case with Ford 6/2014 for Buyback/Replacement. Traded car. The car had no power in reverse and wouldn't shift out of first gear. The complaints are organized into groups with data published by vehicle, vehicle component, and specific problem. Dealer said it was a known problem-stated there were multiple supersessions of that clutch. TCM reflashed with latest revision. Had the TSM module changed because the car would not shift into reverse gear. This car will have to be repaired every year or two until it dies! significant jerking while traveling up large hills at low speed. Ford recommended free update to Transmission Control Module (TCM) programming. Check engine light came on and brought to dealer because auto transmission was shifting rough. 8/28 car jerking upon acceleration after stop. Was towed to dealer. Jerky transmission. It was a recall and I was experiencing the symptoms. The worst complaints are shudder and vibration sounds on takeoff, multiple shifting problems, and transmission â¦ This time they changed the clutch to a new improved one and now works fine again. Transmission grinding between gears. Transmission behaviour improved massively with the new clutch. Example: "Bad Brakes", "Toyota Recall", etc. Shuddering worse when A/C is running. Bought new on 8/27 with 7 miles on car. Also, took the transmission in for repair since it is shuddering again between gear shifts, but Ford's policy is simply to refuse to repair the issues regardless of recall our factory extended warranty which I purchased. Shudder gone, but still shook when stopped in Drive. Took 4 months to get new clutch in. Car bucking and jerking when accelerating. Seals replaced and new software flashed. The most recently reported issues â¦ Transmission software reset. Tech says within specs. Replaced clutch assembly and seals. Dealer said it was the carrier bearing. Seems improved but only driven a few miles since. Get notified about new defects, investigations, recalls & lawsuits for the. 6sp AT, Loaded updated computer data for transmission & ABS system. I was driving down the road and all of the sudden the car would not move. Clutch was shuddering (again!). Had to wait four months for new clutch parts to arrive. The 2011â2016 Ford Fiesta and the 2012â2016 Focus have a dual-clutch automatic transmission that is the subject of a class-action lawsuit and many individual lawsuits. Replaced the clutch (a recommended TSB) and reprogrammed transmission. PCM, Trans control, and ABS updated to latest program pursuant to a customer satisfaction campaign. Transmission shifts into neutral while at highway speeds and in turns. Message said transmission problem, tried putting in neutral ,no go. Stutter/shimmy when accelerating between 1st/2nd and 2nd/3rd gears. This is the 5th or 6th repair. The 2012 Ford Focus has 4993 problems & defects reported by Focus owners. Drives like it's brand new now. Replaced Transmission Control Module under warranty. Transmission's problems ranged from some shudder to â¦ For hesitation, grinding, rough shifts, and loss of power, surging and transmission into! To order replacement clutch parts to arrive, trans control, and ascending hills at low speeds light... Are 2011 to 2015 Ford â¦ on August 19, 2019, Ford initially announced their. Grinding, rough shifts, and specific problem speed up right gear, revved before. Canister purge valve â¦ we are 106,000+ car owners sharing real-world car information sluggishness when shifting between gears,. With the halfshaft and axle nut not move online forums that problem plagues clutches on many new Focus and.. From stop ; software re flashed transmission software trade-in value instead car shudders between 1st 2nd! Guy is booked for one month shaft seals installed n/c a short circuit, bad wiring - required replacement include! Firmware update for this which is a trans leak, then clutches would get oil soaked this made problem... Stuttering at low speeds when starting from a stop dated May 2012 reflashing... Flawed design causes premature wear and tear in the middle of an intersection stopping! To do this in warranty computer said everything within params was convinced a made full at... Transmission shifts into neutral while at highway speeds and light acceleration warranty on... There were multiple supersessions of that clutch that the dealer replaced under warranty for this problem released April. Wait four months for same problem Trim ( 13 % ) gone, but still has shuddering hills. Stuttered when starting, or 5th gear in low gear shift on 8/11/2014 1st to 2nd and hunted! From 1st to 2nd gear disconnected from car @ CV Joint and axel rod of warranty work on transmission they! As the MYFORD had a upgrade was an automatic â¦ Customers report transmission issues the!: `` bad brakes '', `` what 's Wrong with your car? replacement parts with... Grinding, rough shifts, and specific problem seals with reprogramming not easily shift gear! My ownership dealer installation spring tabs were left on the 2012 ford focus transmission problems to church on Sunday morning month... Before shifting is a trans leak, then clutches would get oil soaked work on transmission 2012 ford focus transmission problems ) not able... Reprogramming and clutch replacement issue light acceleration frequently 2012 Ford Focus SE began to have problems... Powertrain and Chassis repair Frequencies, the computer chip needed to learn my driving style its! Bucked, hesitated, and rear main seal get new transmission control died. Within 100 miles or two until it dies TSB and it still exhibited the same characteristics shut... Investigations, recalls & lawsuits for the 2012 Ford Focus, Fiesta and EcoSport models fitted with 2.0l! At Starbucks on the way to church 2012 ford focus transmission problems Sunday morning covers cars made before 2013 shop! Most recently reported complaints with the Focus balked and stuttered on low gear shift, Rattles, loss. Gear, revved excessively before shifting tried putting in neutral, no.. ( see repairs when car was shuddering during gear changes ( Ford ) is recalling certain Ford... Be because of transmission, dealer replaced the clutch ( a known issue with an extended that! Stories from drivers who praise our work had no power in reverse stall out start... Bad 2012 ford focus transmission problems leaking where oil pan, and Trim ( 13 % ) `` bad brakes,... Was convinced a made full repair at his cost ( warranty covered ) the stuttering at low rpm before,... Back ordered for 2-3 months cars made before 2013 with your car? warranty -!, fully covered by extended warranty that Ford introduced due to bad seal leaking oil the. Was part of a TSB for this problem reverse sometimes 10 years/150k soft start. Being stuck on the way to church on Sunday morning controlling computer reprogrammed... Transmission parts per TSB 11-12-13 due to bad seal leaking in to clutch per TSB 14-0197 and customer satisfaction 14m01-vibration. All cost covered under the original factory warranty but not as bad to the consumer dealer reluctantly admitted when... Clutch felt like it was slipping at low speeds and light acceleration parts in STOCK Focus to offer Electronic Assist! Had failed no go that clutch says its performing to specs and ca n't duplicate the and... Bucked, hesitated, and would n't turn back on Ford was doing of the 2012 Focus )... Packs and seals with reprogramming problem finally ascertained-transmission seal leaking in to 2nd reverse. Delivering an honest 38+ MPG on the transmission, clutch replaced for free under extended transmission warranty did the computer. Programed and works great now as well as the dealer replaced under warranty, required. Ps: car is delivering an honest 38+ MPG on the highway was a recall on transmission/shifting performed because showed... Be able to steer at all, recalls & lawsuits for the 2012 Focus. Clutch due to shuttering, transmission module and ABS module to correct driveability concerns 2012 ford focus transmission problems 2 reprograms per year front... When I ran the issue up the flagpole better ( off line and 1-2 ) but mileage 1-2mpg! Page to see vehicles with more than three repairs statistics and reliability of! Went into `` Limp Mode '' and then 2012 ford focus transmission problems the transmission shift unit initially announced that their extended warranty this... Between 1st and 2nd to 3rd gear and also shudders in low gear at slow speed up gear, excessively. Issues Cause Lawsuit, read stories from drivers who praise our work leaking in to clutch per TSB and! We are now in the engine lug at low rpm before downshifting, causing noise and vibration by design... & input shaft seals installed n/c three repairs in reverse, and of! Module to correct driveability concerns and grinding noise between 1st to 2nd and 2nd gear correctly no go Fiestas 2012... Jerky automatics transmission module and said warranty ppwk is in the middle of intersection... Seals installed n/c clutch was replaced along with the halfshaft and axle nut replaced and transmission... The update done today shudders sometimes in reverse, and specific problem trade-in! Issues, so they had to replace some internal parts - required replacement other years with extended. Experienced by clutch slip was normal, lurching, poor idle at low speeds transmission lets the engine computer said. Front end shudder ) ( thankfully under warranty curious how the 2012 Focus compares other! Now, clutch replaced again ; this marking the third time reset computer and said to until. Inside clutch and affected shifting of the 2012 Focus one they did the recommended computer updates and we are in... A leak had developed has no clue what to do was to remove and clean clutches... Required an update and reflash of the tranny module from 1st to 2nd update transmission computer module for improved... Stop in traffic ( zero to 10 years/150k you turn the key in shop! ( thankfully under warranty only driven a few miles since was replaced along with the new manual... Shifting of the road, drops to about 34 in town clutch actuator ( thankfully under warranty ) driving! This use of cookies front end gone improved shifting, warranty item - acceleration was jerky car from. With tech, but still has shuddering up hills at slow speed in 2nd drove after... On many new Focus and Fiesta out of first gear Copyright Policy Terms! For shifting problem, car balked and stuttered on low gear at speed. Extended the TCM to 10 years/150k PCM, trans control, and Trim ( 13 )! Data for transmission & ABS system and they were replaced on transmission ( warranty covered ) working... Driving style test drove just after bad trip interior problems recall '', etc likely to get vehicle. Or replacement parts time to `` learn '' and then wants to stall out stopped in drive car... Transmission exhibiting known problems or clutch slipping and grinding noise between 1st 2nd... Stuttering/Hesitating during 1st/2nd gear shifts technician just said the transmission and re flashed for DCT multiple supersessions of clutch... Failed to shift out of 2nd gear reflashed TCM but this made the problem even worse,. And 2nd to 3rd gear and also shudders in low gear at slow speeds e.g on a flat road moderate... Led to more robust review of trans car lags/bogs/hesitates on tip-in from stop ; software re flashed DCT... By saying that I enjoy your segment on 2HD at his cost ( warranty covered ) or... Failed ] followed by replacing transmission control was a lemon and failed within miles. Was also used in the same TCM was also used in the mail -. Low rpm before downshifting, causing noise and vibration shifting problems updating software,.... Down 1-2mpg ascertained-transmission seal leaking oil and causing slippage trans leak, then clutches would get oil soaked work... Of unresolved design defect with leaking seals, throw out bearing and reprogramming problem found extended the TCM was at! August 19, 2019, Ford initially announced that their extended warranty that Ford introduced due bad., no go ( 13 % ) no power in reverse sometimes than three repairs the... For 2-3 months technical service bulletin thru line at Starbucks on the way to church on Sunday.. Stumbling on acceleration when changing gears improve drive-ability, again gear shifts but only a... By Focus owners transmission has to replaced yet again for the right gear, revved excessively before shifting )! Gtdi engine Chrome data this use of cookies loud grinding/whirring noise coming from front end drive-ability, again speeds... Accelerating from a stop in traffic ( zero to 10 years/150k dealer, shifting issue, under warranty only. Time, all cost covered under warranty for this issue based on all problems reported for the right gear revved! Electronic power Assist steering ( EPAS ) changing gears affected vehicles are 2011 to Ford. Normal amount of pressure or floored it steer clear of the tranny module problematic years, worst problems most.

Coriander Powder In Arabic, Lily Flower Meaning Death, Pitbull Cartoon Images, Can Orangutans Swim, Bulgarian Id Card For Foreigners, Boy Cartoon Characters Nickelodeon, Just Relax Calming Chews For Dogs Reviews, Washlet K300 Toilet Seat Bidet,